Product ID:BNV 40T SOFT TONER PREMIX
MSDS Date:01/01/1989
FSC:6850
NIIN:00N020287
MSDS Number: BLHVJ

GRAPHIC CONTROLS CORPORATION

189 VAN RENSSELAER STREET
BUFFALO, NY 14240
US

Emergency Phone: 716-853-7500

Info Phone: 716-853-7500

Cage: 17405

GRAPHIC CONTROLS CORP INDUSTRIAL PRODUCTS DIVISION

1309 BUFFALO, NY 14240 US

Telephone: 716-853-7500

Cage: 17405

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 0.1 - 1%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3; 9192

C*10, C*11 ISOPARAFFINIC HYDROCARBON

CAS: 31807-55-3

Fraction By Weight: 0.1%

C*10, C*11 ISOPARAFFINIC

CAS: 64742-48-9

Fraction By Weight: 2-3%

SOLVENT NAPHTHA

CAS: 64742-94-5

RTECS: WF3100000

Fraction By Weight: 96.4-97%

VM&P NAPHTHA (LIGROINE)

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: 0.2%

OSHA PEL 300 PPM/400 STEL

ACGIH TLV: 300 PPM; 9192

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE IRRITANT:PROLONGED OR
REPEATED SKIN CONTACT WITH PRODUCT TENDS TO REMOVE SKIN OILS
POSSIBLY LEADING TO IRRITATION AND DERMATITIS. HIGH VAPOR
CONCENTRATIONS (GREATER THAN APPROXIMATELY 1000 PP M) ARE
IRRITATING TO EYES AND RESPIRATORY TRACT, MAY CAUSE HDCH & DIZZ,
ARE ANESTHETIC & MAY HAVE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:OTHER CENTRAL NERVOUS SYSTEM EFFECTS.
ANIMAL STUDIES HAVE SHOWN THAT KIDNEY EFFECTS CAN OCCUR IN MALE
RATS AFTER PROLONGED AND REPEATED INHALATION. WHILE EFFECTS ARE OF
LOW ORDER OF SEVERITY IN ANIMALS, THE IMPLICATIONS OF THESE
RESULTS FOR HUMANS HAVE NOT YET BEEN DETERMINED. LOW ORDER OF ACUTE
ORAL (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. IF IRRITATION
PERSISTS, CALL MD. SKIN:REMOVE ANY CONTAMINATED CLOTHING AND WASH
SKIN THOROUGHLY WITH SOAP & WATER. INGEST:DO NOT INDUCE VOMITING.
CALL MD IMMEDIATELY. INHAL:IF OVERCOME BY VAPOR, REMOVE FROM
EXPOSURE AND CALL MD IMMEDIATELY. IF BREATHING IS IRREGULAR OR HAS
STOPPED, START RESUCITATION, GIVE OXYGEN, IF AVAILABLE.

Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:0.8%
Upper Limits:7%
Extinguishing Media:FOAM, WATER SPRAY (FOG), DRY CHEMICAL, CO2.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:DO NOT EXPOSE TO FLAME OR EXCESS HEAT.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. RECOVER FREE
PRODUCT. ADD SAND, EARTH OR OTHER SUITABLE MATL TO SPILL AREA.
MINIMIZE BRTHG VAPS & SKIN CONTACT. VENTILATE CONFINED SPACES. KEEP
PRODUCT OUT OF SEWERS & WATERCOURSES BY DIKING OR IMPOUNDING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NORMALLY NOT NEEDED. NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:USE WITH ADEQUATE VENTILATION.
Protective Gloves:NONE SPECIFIED BY MANUFACTURER.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:TOXICITY, BUT MINUTE AMOUNTS ASPIRATED INTO LUNGS MAY
CAUSE SEVERE PULMONARY INJURY OR DEATH.

HCC:F4
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:<10
Spec Gravity:O.75-0.80
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID WITH MILD ISOPARAFFINIC HYDROCARBON
ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM
HYPOCHLORITE OR CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH ALL LOCAL,
STATE, AND FEDERAL REGULATIONS .

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.